Product ID:CARBON DIOXIDE GAS
MSDS Date:03/09/1993
FSC:4210
NIIN:01-073-5561
MSDS Number: BPZTQ

Emergency Phone: 715-735-7411

Info Phone: 715-735-7411

Preparer: DGSC-SSH

Cage: 03670

Telephone: 715-735-7411

Cage: 03670

CARBON DIOXIDE

CAS: 124-38-9

RTECS: FF6400000

Fraction By Weight: 100%

OSHA PEL 5000 PPM

ACGIH TLV: 5000PPM/30000STEL;93

LD50 LC50 Mixture:TLV & PEL IS 5000 PPM
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: PROLONGED CONTACT CAN CAUSE
SLIGHT IRRITATION. AVOID BREATHING OF VAPOR WHICH IS HEAVIER THAN
AIR AND CAN CAUSE SUFFOCATION BY REDUCED OXYGEN. CONTACT WITH CO2
SNOW (DRY ICE) CAN PRODUCE CH LILLING SENSATIONS AND DISCOMFORT;
POSSIBLE FROSTBITE.
Explanation of Carcinogenicity:CARBON DIOXIDE IS NOT KNOWN TO BE A
CARCINOGEN.
Effects of Overexposure:IRRITATION OF EYES/SKIN/RESPIRATORY TRACT.
BREATHING VERY HIGH CONCENTRATIONS OF VAPOR CAN CAUSE
LIGHTHEADEDNESS, GIDDINESS, SHORTNESS OF BREATH, MUSCULAR TREMORS
AND WEAKNESS, HEADACHES, TINNITUS, AC ROCYANOSIS, UNCONSCIOUSNESS
AND DEATH IN EXTREME CASES.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF SKIN AND
RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.

First Aid:EYE: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION. SKIN: WASH WITH SOAP AND WATER. INHALATION:
REMOVE TO FRESH AIR.

Flash Point:NONFLAMMABLE
Lower Limits:NOT RELEVANT
Upper Limits:NOT REVELANT
Extinguishing Media:THIS MATERIAL IS AN EXTINGUISHING AGENT.
Fire Fighting Procedures:USE STANDARD FIRE FIGHTING PROCEDURES WHEN
USING THIS MATERIAL
Unusual Fire/Explosion Hazard:NONE SPECIFIED BY MANUFACTURER.

Spill Release Procedures:MATERIAL WILL QUICKLY EVAPORATE AND DISSIPATE.
Neutralizing Agent:NONE

Handling and Storage Precautions:STORE IN A COOL (<120F), DRY, WELL
VENTILATED AREA AWAY FROM SOURCES OF IGNITION. KEEP CONTAINER
CLOSED WHEN NOT IN USE. PROTECT FROM PHYSICAL DAMAGE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS
PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND
NIOSH-RESPIRATOR SELECTION.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS USUALLY ADEQUATE.
Protective Gloves:THERMAL PROTECTIVE FOR HANDLING DRY ICE
Eye Protection:SAFETY GLASSES/CHEMICAL SPLASH GOGGLES
Other Protective Equipment:PROTECTIVE CLOTHING FOR HANDLING DRY ICE.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
PREVENT DAMAGE TO GAS CYLINDERS. MSDS GENERATED BY DGSC-SSH FROM OTHER
CARBON DIOXIDE FIRE EXTINGUISHER SUPPLIED BY ANSUL CORP.

HCC:G3
Vapor Pres:830
Vapor Density:1.5
Spec Gravity:1.98
Evaporation Rate & Reference:NOT GIVEN
Solubility in Water:88ML CO2/100 ML H2O
Appearance and Odor:COLORLESS,ODORLESS GAS
Percent Volatiles by Volume:100 %

Stability Indicator/Materials to Avoid:YES
ALUMINUM-SODIUM PEROXIDE MIX, LI, K, MG, NA, TI, SUPEROXIDES,
ORGANOMETALLIC COMPOUNDS, CS2O
Stability Condition to Avoid:HIGH TEMPERATURE WHICH COULD CAUSE RUPTURE
OF THE TEMPERATURE AND PRESSURE RELIEF DEVICES.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.